High-rise MEP contracting in Al Taawun 

High-rise MEP contracting in Al Taawun: local context

Al Taawun runs along the northern shore of Al Khan Lagoon near Expo Centre Sharjah, a district of residential high-rises, office towers and shopping centres built mostly from the 2000s. Its towers sit on podium car parks fronting a busy main road. The area combines new developments with towers now due for system upgrades. Traffic along Al Taawun Road is heavy throughout the day.

• Office and residential towers typically use central chilled-water plants with cooling towers or air-cooled chillers; replacement projects must keep cooling running while old plant is removed.
• Expo Centre events and lagoon-side traffic create congestion peaks, so crane lifts and deliveries are scheduled around event days.
• Lagoon humidity and salt drive corrosion on roof equipment and podium-level plant, so coatings and inspection regimes matter.

Building types we serve in Al Taawun

For high-rise towers, the work concentrates on pressure-zoned water and drainage stacks, riser and plant-room coordination, stair pressurisation and a cooling source sized for diversity across dozens of typical floors.

Scope of work

• Riser design and installation for chilled water, drainage, fire mains, electrical busbars and low current, with expansion joints and supports suited to building movement.
• Smoke control and stair pressurisation systems, including fans, dampers and controls, coordinated with fire alarm cause and effect.
• Typical-floor MEP installation using repeatable layouts and prefabrication where possible to speed installation and improve quality.
• Testing, commissioning and phased handover by floors or zones as required by the developer, with life-safety systems proven before any floor is occupied.

Systems we install

• Busbar risers, floor DBs, emergency generators and life-safety panels.
• Domestic water booster sets, PRV stations and break tanks.

UAE site and climate challenges

• Tall buildings in humid coastal areas need strict control of outdoor air at each floor. Dedicated fresh-air units with dehumidification prevent condensation on ceilings and moisture problems in corridors and apartments.
• Stack effect in tall buildings pushes air through stairs and lift shafts, especially with large indoor-outdoor temperature differences. Pressurisation design and door leakage assumptions take this into account so doors remain openable during an emergency.
• Prefabricated riser modules: speed and quality on site improve noticeably, but the design must be frozen early and crane time, storage and delivery sequence must be planned months in advance.

Relevant Manolia projects

Two Nahda residential towers, Sharjah

Al Nahda (Sharjah) · MEP · Completed

MEP for two towers of 23 and 24 typical floors over parking podiums.

G+11 twin

G+11 twin tower A/C renovation, Sharjah

Sharjah · HVAC · Completed

Air-conditioning replacement in occupied twin towers.

Frequently asked questions